Waste Heat Recovery System (WHRS) -

increasing the exhaust gas temperature before the boiler without using a power turbine. When applying the steam turbine (ST) as a stand-alone solution, the exhaust gas bypass stream is mixed with the exhaust outlet from the turbocharger(s), increasing the exhaust gas temperature before the boiler inlet. When part of the exhaust gas flow is

learn More

Fire in exhaust gas boiler - GARD

The exhaust gas pipe from the main engine to the exhaust gas boiler measured 50cm in diameter and was installed at the lower starboard side panel of the casing. A few hours after the vessel had berthed, the crew discovered that the exhaust gas boiler wall had heated up and was glowing red. The chief engineer was informed and the fire alarm was

learn More

Exhaust gas boilers (CO-GEN) | Danstoker

Exhaust gas boilers (CO-GEN) Over the past few decades, Danstoker has delivered more than 2,500 exhaust gas boilers worldwide and has gained an unparalleled expertise in this field. The boilers are fitted after gas or diesel engines or gas turbines.

learn More

Boiler Uptake Fire and Exhaust Gas Economiser Fire

Aug 27, 2015· Fuel oil used for boiler to be treated well. Avoid low load operation of boiler for long period. Running boiler near full load periodically, helps in expelling out carbon deposits adhered in uptake passages and reduces chances of boiler uptake fire considerably. What is exhaust gas economiser (EGE) fire and how it occur ?

learn More

Engine Exhaust Back Pressure - DieselNet

Engine exhaust back pressure is defined as the exhaust gas pressure that is produced by the engine to overcome the hydraulic resistance of the exhaust system in order to discharge the gases into the atmosphere. For this discussion, the exhaust back pressure is the gage pressure in the exhaust system at the outlet of the exhaust turbine in

learn More

Heat Recovery Silencer - Thermal Transfer Systems

diesel engines, gas turbines, and micro turbine generator retrofit Recirculating engine jacket water boilers. EXHAUST STEAM GENERATOR The fully packaged ESG1 is selected from 48 pre-engineered standard The HRS Radial waste heat recovery silencer is a module,,, * 3/

learn More

Boiler - wartsila.com

- Exhaust gas boiler, economiser An exhaust gas heat exchanger is a row of tube banks circulted by feed water over which the exhaust gases from main diesel engine flow. A boiler drum is required for steam generation and separation to take place. For this purpose, the drum of an auxiliary boiler

learn More

Exhaust gas heat recovery boiler - alfalaval.com

The Aalborg AV-6H exhaust gas boiler is a water tube boiler for heat recovery, typically after gas engine. The boiler comes in a horisontal layout and compact work-shop assembled module. It is easy and fast to install while allowing maximised access for convenient maintenance and service. High-efficient counterflow design for heating of hot

learn More

How do Boilers Work & What is their Use on Ships?

The exhaust gas of the boiler is also put to use by making it pass over an air heater, which heats up the combustion air entering the furnace. Thus, even the energy exhausted from the boiler is not allowed to go waste, which increases the overall efficiency of the system.

learn More

Exhaust Gas Heater - GESAB - Göteborg Energy Systems AB

GESAB-HTI Exhaust Gas Heaters, heated by waste gases from the vessels's main engine, is commonly used in satisfying the heat demand of the vessel's bunker heating, accommodation, calorifier water and pre-heaters during the voyage. It may also be sufficient to heat the cargo, subject to heat requirement. Design and construction:

learn More

Exhaust Gas Steam Boiler

Exhaust Gas Boilers also known as Exhaust Gas Economizers, with extended heating surface, used for waste heat recovery in motor ships. A diesel engine loses approximately 30% of the energy to the exhaust gases. A turbocharger recover some of it, but there is still heat losses that can be recovered by means of an Exhaust Gas Boiler, EGB.

learn More

How do Boilers Work & What is their Use on Ships?

The exhaust gas of the boiler is also put to use by making it pass over an air heater, which heats up the combustion air entering the furnace. Thus, even the energy exhausted from the boiler is not allowed to go waste, which increases the overall efficiency of the system.

learn More

Exhaust gas boiler - Engine & fuel engineering - Eng-Tips

Hi everyone. I have gas engine that should be equipped with exhaust gas boiler. How to determine the specific heat of exhaust gas when I dont have the measurement value of percentage volume composition of engine exhaust gas? or anyone have some guidance or calculation step to determine design of exhaust gas boiler?

learn More

boiler exhaust | eBay

Find great deals on eBay for boiler exhaust. Shop with confidence. Skip to main content. eBay Logo: METAL-FAB 18 PIC IPIC VENT ACCESSORIES 18" ENGINE / BOILER EXHAUST See more like this. Universal Air Pressure Switch Strong Exhaust Gas Boiler Water Heater Repair Part See more like this.

learn More

Exhaust Gas Steam Boiler

Exhaust Gas Boilers also known as Exhaust Gas Economizers, with extended heating surface, used for waste heat recovery in motor ships. A diesel engine loses approximately 30% of the energy to the exhaust gases. A turbocharger recover some of it, but there is still heat losses that can be recovered by means of an Exhaust Gas Boiler, EGB.

learn More

Is a high efficiency, condensing gas boiler the best

Aug 13, 2018· When fuel is burned in a boiler, it produces flue gas, similar to the exhaust from your car. This gas leaves the combustion chamber and enters the flue passages. The combustion chamber and flue passages (called the heat exchanger) are surrounded by water the same water that is circulated throughout your home to deliver heat.

learn More

Boiler uptake fire and exhaust gas economizer fire

Generally, an exhaust gas economizer is described as a smoke tube boiler with steam space, used for heat recovery from the main engine exhaust gas. Flue gases or auxiliary boiler uptake normally pass through economizers, air preheaters or feed water heaters. All these types of Author: KbadminExhaust gas boilers (CO-GEN) | Danstokerdanstoker.com/product-search/exhaust-gas-boilers-co-genExhaust gas boilers (CO-GEN) Over the past few decades, Danstoker has delivered more than 2,500 exhaust gas boilers worldwide and has gained an unparalleled expertise in this field. The boilers are fitted after gas or diesel engines or gas turbines.

learn More

Exhaust Gas Steam Boiler

Exhaust Gas Boilers also known as Exhaust Gas Economizers, with extended heating surface, used for waste heat recovery in motor ships. A diesel engine loses approximately 30% of the energy to the exhaust gases. A turbocharger recover some of it, but there is still heat losses that can be recovered by means of an Exhaust Gas Boiler, EGB.

learn More

Exhaust gas boilers on auxiliary engines - glomeep.imo.org

Exhaust gas boilers recover the heat from the exhaust gas of auxiliary diesel engines to generate steam and/or hot water, or useful heat for process heating. Depending on system design, these boilers can enhance the efficiency of the auxiliary engine system by up to 20%, leading to lower overall process costs. See Figure 1.

learn More

Exhaust Gas Heat Exchanger | Kelvion

Its compact and modular design makes it extremely versatile and easy to service. Our exhaust gas heat exchanger is designed to recover heat from exhaust gas produced for example by combustion engines used in combined heat and power plants.

learn More